1、 Check carefully and deal with the fault detection in time

1、不可以重車壞在路上，不然發生悶罐就麻煩了，混凝土通常停罐不可以超出兩個鐘頭，C40往上級別的混凝土基本就不可以停。

1. It is not allowed that heavy vehicles break down on the road, otherwise it will be troublesome to have a stuffy tank. Generally, the concrete tank can not be stopped for more than two hours, and the C40 concrete can not be stopped basically.

2、打火前先查驗機油、防凍液、潤滑油和冷卻水等，發覺不夠時，應再次進行加上。

2. Check the engine oil, antifreeze, lubricating oil and cooling water before ignition. If it is found that they are not enough, add them again.

3、3方水泥自動攪拌車開啟后，再讓罐子低速旋轉，圍繞著車查驗輪胎氣壓，是不是有漏氣的胎，再用螺絲刀剔掉在胎縫中的碎石子，查驗。

3. After the 3-cube concrete mixer is started, let the jar rotate at a low speed, and check the tire pressure around the truck to see if there is a leaking tire. Then use a screwdriver to remove the broken stones in the seam of the tire to check.

4、是不是有釘子之類扎在胎里。

4. Is there a nail or something stuck in the tire.

5、再查驗燈光，尤其是腰燈，盡量保障照著3方水泥自動攪拌車車胎邊緣，施工工地會經常亂堆放鋼筋之類的物品，而胎側是較薄弱的。

5. Check the light, especially the waist light, to ensure that it shines on the edge of the tire of the concrete mixer truck. The construction site will often pile up things like steel bars, and the sidewall is relatively weak.

6、用毛巾擦干凈兩邊的后視鏡，窗戶玻璃，施工工地路況復雜，光線不太好，視野要有保障。

6. Clean the rear-view mirrors and window glass on both sides with a towel. The road conditions on the construction site are complex, the light is not very good, and the vision should be guaranteed.

二、保障水箱里有充足的水，有減水劑

2、 Ensure that there is sufficient water in the water tank and water reducing agent

因各種各樣原因料太干，沒有水加上放不出料的情況下，減水劑便是救命稻草。

Because of various reasons, the material is too dry, there is no water and the material can not be discharged, the water reducer is the life-saving straw.

三、確認3方水泥自動攪拌車的攪拌罐處在停止?fàn)顟B(tài)

3、 Confirm that the mixing tank of cubic concrete mixer is in stop state

由于發動機運作時要是罐子處在高速旋轉狀態，一瞬間的力會非常大的，傷減速機。3方水泥自動攪拌車會將混凝土運輸，而且提供拌和功能，如此一來混凝土?xí)芩绍?，不容易干結。出車前，要多多查驗3方水泥自動攪拌車的一些狀況，例如方向盤車胎是不是一切正常，查驗明確沒什么問題以后再駕駛。

When the engine is running, if the can is in a high-speed rotating state, the instantaneous force will be very large, which will damage the reducer. The concrete mixer truck will transport the concrete and provide mixing function. In this way, the concrete will be very soft and not easy to dry. Before driving, check the condition of the concrete mixer truck, such as whether the steering wheel tire is normal or not, and then drive it after checking that there is no problem.