1、 Advantages and characteristics of Zhongke Jufeng automatic loading mixer compared with traditional mixer the independence of automatic feeder: the automatic feeder can be operated independently to complete the functions of loading, mixing, conveying, unloading, etc.

　　2. 自動攪拌車多功能:自動攪拌車取代裝載機、混合機、輸送機、發電機組等功能;它還擁有自己的水箱，外吸泵，自動上料攪拌機，其中有水供應給攪拌機連續;由于該材料攪拌器可適用于整座山，具有很實用的性能。30度的斜坡很容易攀爬。多角度270度旋轉卸貨，適合多種不同地理環境。

　　2. Multiple functions of automatic loading mixer: automatic loading mixer replaces loader, mixer, conveyor, generator set and other functions; it also has its own water tank, external suction pump, automatic loading mixer, in which water is supplied to the mixer continuously; because the material mixer can be applied to the whole mountain, it has very practical performance. A 30 degree slope is easy to climb. Multi angle 270 degree rotary unloading, suitable for a variety of different geographical environments.

　　3.自動攪拌車操作簡單，只需兩個人即可完成生產。司機操作自動程序，其他人做一些輔助工作。

　　3. The automatic feeding mixer is easy to operate, and only two people are needed to complete the production. The driver operates the automatic program and others do some auxiliary work.

　　4、自動上料攪拌機性價比高:自動上料攪拌機，節省裝載機、攪拌機、運輸車、發電機組、水車等設備的成本和人工成本，節省時間和精力，合理，性價比高。

　　4. High cost performance of automatic feeding mixer: automatic feeding mixer saves the cost and labor cost of loader, mixer, transport vehicle, generator set, water truck and other equipment, saves time and energy, reasonable price and high cost performance.

　　5、自動攪拌車功率大，滿馬力可適應多種環境。

　　5. The automatic feeding mixer has high power and can adapt to various environments at full horsepower.

　　6. 自動攪拌車節省時間:自動上料攪拌器為自動上料攪拌器的料箱節省少10分鐘的上料時間。機器自動化減少了生產時間。從喂食到排出只需12分鐘。攪拌罐可旋轉270度，攪拌車可將物料向多個方向排出，不需要移動一分錢。

　　6. Time saving of the automatic feeding mixer: the automatic feeding mixer saves at least 10 minutes of feeding time for the hopper of the automatic feeding mixer. Machine automation reduces production time. It only takes 12 minutes from feeding to discharge. The mixing tank can rotate 270 degrees, and the mixer can discharge materials in multiple directions without moving a penny.

　　二、自動攪拌車的規范

　　2、 Safety Specification for Zhongke Jufeng automatic loading mixer1、由于物料攪拌車應實施兩級漏電保護，在上班前，先將電源接通，仔細檢查，通過空車試驗并認為合格，方可使用。試車時應檢查滾筒轉速是否合適。一般情況下，空車的速度比空車快2~3轉(裝完貨后)。如有較大差異，應調整主動輪與主動輪的比例。

　　1. As the material mixer shall be protected by two-level leakage protection, before going to work, the power supply shall be connected and checked carefully. It can only be used after passing the empty car test and being qualified. During the test run, check whether the drum speed is appropriate. Generally, the speed of an empty car is 2-3 revolutions faster than that of an empty car (after loading). If there is a big difference, the proportion of driving wheel and driving wheel should be adjusted.

　　2. 自動攪拌車滾筒的旋轉方向應符合箭頭指示的方向。如不正確，應糾正電機接線。

　　2. The rotation direction of the drum of the automatic feeding mixer shall conform to the direction indicated by the arrow. If not, correct the motor wiring.

　　3.檢查傳動離合器、制動器是否靈活可靠，鋼絲繩是否損壞，軌道滑輪是否完好，四周是否無障礙，各部件是否潤滑等。

　　3. Check whether the transmission clutch and brake are flexible and reliable, whether the steel wire rope is damaged, whether the track pulley is in good condition, whether there is no obstacle around, and whether all parts are lubricated, etc.

　　4、自動攪拌車應設置在平位置，用方木墊在輪軸前后，使輪胎設置在高蹺上，以免跑偏。

　　4. The automatic loading mixer shall be set in the flat position, with square wood pad in front of and behind the wheel axle, so that the tire is set on stilts to avoid deviation.

　　5. 自動加載機完成后與混凝土攪拌或預計停留超過1 h,除了排出剩下的材料,用石頭和水搖缸,啟動機器,打開它,并刪除所有迫擊炮堅持沖洗干凈后的氣缸。桶內不得有水，以免生銹。同時，應清理混合筒外的灰塵，以保持機器的清潔和完整。

　　5. After the completion of the automatic loader, mix with the concrete or it is expected to stay for more than 1 h, except for discharging the remaining materials, shake the cylinder with stones and water, start the machine, open it, and delete all the cylinders after the mortar insists on washing. There shall be no water in the barrel to avoid rust. At the same time, the dust outside the mixing drum shall be cleaned to keep the machine clean and complete.

　　6. 自動攪拌車啟動后，要時刻注意混合器各部分的運轉是否正常。機器停機后，檢查混合器葉片是否彎曲，螺絲是否松動或斷裂。

　　6. After the automatic feeding mixer is started, always pay attention to the normal operation of all parts of the mixer. After the machine stops, check whether the mixer blades are bent and whether the screws are loose or broken.

　　7. 下班后，機器不使用時，應切斷電源，并鎖上開關箱，以確保。

　　7. After work, when the machine is not in use, cut off the power supply and lock the switch box to ensure safety.

　　以上文章由小編整理，未經允許不得轉載，如需了解更多關于自動攪拌車廠家及新自料攪拌機信息，請關注本網站。

　　The above article is compiled and sorted by Zhongke Jufeng. It can't be reproduced without permission. Please pay attention to this website if you want to know more about the price information of the auto loading mixer manufacturer and the latest self feeding mixer.