The braking safety of the self loading cement mixer truck is crucial, and the following are some points to be noted:
1.檢查制動系統：在每次啟動車輛前，一定要檢查制動系統是否正常。包括剎車片和剎車鼓的磨損程度，制動液的水平等。
1. Check the braking system: Before starting the vehicle every time, be sure to check whether the braking system is normal. Including the wear degree of brake pads and brake drums, and the level of brake fluid.
2.避免急剎車：自上料水泥攪拌車的車身比較高，急剎車會導致車身前傾，容易導致側翻。因此，駕駛員需要避免急剎車，盡量保持平穩的行駛狀態。
2. Avoid sudden braking: The body of the self loading cement mixer truck is relatively high, and sudden braking can cause the body to lean forward and easily cause rollover. Therefore, drivers need to avoid sudden braking and try to maintain a smooth driving state.
3.注意距離：自上料水泥攪拌車因為體積比較大，行駛時需要注意與其他車輛和行人的距離，以免發生碰撞事故。
3. Attention to distance: Due to the large volume of the self loading cement mixer truck, it is necessary to pay attention to the safe distance from other vehicles and pedestrians when driving to avoid collision accidents.
4.注意制動時間：在行駛過程中，駕駛員需要留意制動時間，避免持續制動時間過長，以免制動器過熱而導致剎車失靈。
4. Pay attention to braking time: During driving, the driver needs to pay attention to the braking time to avoid prolonged braking, so as to avoid overheating the brake and causing brake failure.
5.保持剎車干燥：雨天行駛時，需要注意制動器的干燥狀況，避免制動器潮濕而導致剎車失靈。
5. Keep the brake dry: When driving in rainy days, it is necessary to pay attention to the dry condition of the brake to avoid brake failure caused by the wet brake.
此外自上料水泥攪拌車踩剎車時發抖這種情況大多出現在老車身上，因為使用磨損，混凝土攪拌車剎車盤片表面平整度已經有失準了。所以建議是視情況選擇采用車床光盤工藝打磨，又或者更換剎車片(對于車齡較大的混凝土攪拌車)。
In addition, the shaking of the self loading cement mixer truck when stepping on the brake mostly occurs on the old car body. Due to wear and tear, the surface flatness of the brake disc of the concrete mixer truck has been inaccurate. Therefore, it is recommended to use a lathe disc process for polishing, or to replace the brake pads (for older concrete mixer trucks), depending on the situation.
自上料水泥攪拌車剎車快停住的時候方向盤總會向一側偏轉，這種情況其實就是我們俗稱的“偏剎”，故障原因主要是自上料水泥攪拌車剎車系統左右分泵對剎車片作用力不均勻?qū)е碌摹?/div>
When the brake of the self loading cement mixer truck is about to stop, the steering wheel will always deflect to one side. This situation is actually known as "biased braking". The main cause of the failure is the uneven force exerted on the brake pads by the left and right wheel cylinders of the self loading cement mixer truck brake system.
而在行駛過程中由于自上料水泥攪拌車剎車盤轉動速度快，分泵作用不均勻在快速摩擦時的差別是很小的，我們也很難感覺到。
During driving, due to the fast rotation speed of the brake disc of the self loading cement mixer truck, the uneven action of the slave pump during rapid friction has a small difference, which is difficult to feel.
開動小型攪拌車前需要熱車十多分鐘才有剎車力，自上料水泥攪拌車剎車系統是由發動機提供壓力推動卡鉗夾住剎車盤(盤剎)，或者是推動剎車盤與剎車鼓發生摩擦(鼓剎)。
Before starting a small mixer truck, it takes more than ten minutes to warm up the truck to have braking force. The brake system of the self loading cement mixer truck uses the engine to provide pressure to push the caliper to clamp the brake disc (disc brake), or to push the brake disc to rub against the brake drum (drum brake).
所以像上述的狀況，可能是提供壓力的傳輸管道出現失壓，導致無法及時提供剎車力。這種情況應檢查剎車總泵的真空助力皮管和自上料水泥攪拌車發動機的借口處是否有龜裂或松脫的狀況。
Therefore, in situations like the above, there may be a loss of pressure in the transmission pipeline that provides pressure, resulting in the inability to provide braking force in a timely manner. In this case, check the vacuum booster hose of the brake master cylinder and the engine of the self loading cement mixer truck for cracks or looseness.
總之，自上料水泥攪拌車的剎車需要駕駛員時刻保持警覺，檢查制動系統的正常性，注意行車距離和制動時間，及時維護保養制動器，確保自上料水泥攪拌車在行駛過程中的。您有怎樣的疑惑或者需求就來我們網站
http://f3328.cn留言咨詢吧！
In short, the braking safety of the self loading cement mixer requires the driver to remain vigilant at all times, check the normality of the braking system, pay attention to the driving distance and braking time, and maintain the brakes in a timely manner to ensure the safety of the self loading cement mixer during driving. If you have any doubts or needs, please come to our website http://f3328.cn Leave a message for consultation!
上一篇：重新來認識一下水泥自動攪拌車設備
下一篇：如何順暢使用自動攪拌車進行相應施工？
