自上料水泥攪拌車是用來運送建筑用混凝土的專用卡車，這類卡車上都裝置圓筒型的攪拌筒以運載混合后的混凝土。在運輸過程中會始終保持攪拌筒轉動，以保證所運載的混凝土不會凝固。運送完混凝土后，通常都會用水沖洗攪拌筒內部，防止硬化的混凝土占用空間。

Self loading cement mixer is a special truck used to transport concrete for construction. Cylindrical mixing cylinders are installed on such trucks to carry mixed concrete. During transportation, the mixing drum will always be kept rotating to ensure that the concrete carried will not solidify. After the concrete is transported, the inside of the mixing drum is usually flushed with water to prevent the hardened concrete from occupying space.

自上料水泥攪拌車的散熱器在使用過程中，會因腐蝕和積垢等原因影響冷卻效果。清洗散熱器，去除水垢，是恢復散熱器的散熱能力的有效方法。車用柴油機進行維護時，須清洗發動機的冷卻系統。若水垢不多，可用水強力沖洗。此時散熱器和發動機水套的沖洗應分開進行。

The cooling effect of the radiator of self loading cement mixer truck will be affected due to corrosion, scaling and other reasons during the use. Cleaning radiator and removing scale is an effective method to restore the heat dissipation capacity of radiator. When the vehicle diesel engine is maintained, the engine cooling system must be cleaned. If there is not much scale, it can be washed with water. At this time, the radiator and engine water jacket shall be flushed separately.

預先將節溫器拆下，并將汽缸蓋上出水彎頭的旁通孔堵塞，用專門的沖洗槍，在供入水的同時，供入壓縮空氣，則沖洗效果較好。沖洗水流的方向應和發動機工作時，水的循環方向相反。為減少水垢，在冷卻系統中盡量是添加軟水;在低溫下使用，盡量添加防凍液。

Dismantle the thermostat in advance, block the bypass hole of the water outlet elbow on the cylinder head, and use a special flushing gun to supply compressed air while supplying water, so that the flushing effect is better. The direction of flushing water flow shall be opposite to that of water circulation during engine operation. To reduce scale, soft water shall be added to the cooling system as much as possible; Use at low temperature and add antifreeze as much as possible.

如果自上料水泥攪拌車的散熱器水垢較多，則應采取化學除垢劑清洗。即利用酸或堿類物質與水垢的化學反應，生成可溶于水的物質將水垢。清洗時，盡量采用循環法，即先用酸性溶液洗滌，再用堿性溶液沖洗中和。

If the radiator of the self feeding cement mixer has more scale, chemical detergent shall be used for cleaning. Namely, the chemical reaction between acid or alkali substances and scale is used to generate water soluble substances to remove scale. When cleaning, the circulation method shall be adopted as far as possible, that is, first use acidic solution to wash, and then use alkaline solution to wash and neutralize.

清洗時，除垢劑以一定的壓力(一般為10l(Pa)，在汽缸體水套或散熱器內循環，一般經3～5min后即可清洗完畢。清洗散熱器時，清洗水套、散熱器的溶液和清洗方法。

During cleaning, the detergent circulates in the water jacket or radiator of the cylinder block at a certain pressure (generally 10l (Pa)), and can be cleaned after 3-5 minutes. When cleaning the radiator, clean the water jacket, radiator solution and cleaning method.

清理自上料水泥攪拌車散熱器的好方式就講解到這里了，您對此有什么疑惑或者需求可以隨時來我們網站http://f3328.cn進行咨詢了解！

This is a good way to clean the radiator of self feeding cement mixer truck. If you have any doubts or needs, please come to our website at any time http://f3328.cn Ask about it!