在混合設備的生產中使用自來水也不是關鍵的自來水階段。由于混凝土凝固后很難，每天清洗平口攪拌車和罐車需要大量的水。那么我們應該如何控制平口攪拌車的用水量呢？

The use of tap water in the production of mixing equipment is not a key tap water stage. Since it is difficult to solve the problem after concrete solidification, it needs a lot of water to clean the flat mouth mixer and tank truck every day. So how should we control the water consumption of flat mixer?

1、根據減水劑的用量或減水率利用率高的減水劑，選擇適應性好的減水劑和混凝土類型。提高砂石配合比，找到砂石配合比對各砂漿配合比，提高和易性，從而減少用水量。

1. According to the dosage of water reducing agent or the water reducing agent with high water reducing efficiency, select the water reducing agent and concrete type with good adaptability. Improve the mix proportion of sand and stone, find the mix proportion of sand and stone and the mix proportion of each mortar, improve the workability and reduce the water consumption.

2、要嚴格檢驗每種材料的性能，控制以上要素，減少用水量。通過使用大量水泥材料來提高可加工性。多檢查砂石含水量，提高責任心，確?；炷撂涠仍诿看纬隽下实目刂品秶鷥?nèi)。

2. Strictly inspect the performance of each material, control the above factors and reduce water consumption. Improve workability by using a large number of cement materials. Check the water content of sand and stone more, improve the sense of responsibility and ensure that the slump of concrete is within the control range of each discharge rate.

3、與攪拌設備施工現場施工單位的溝通非常重要。要想得到施工隊的了解，需要配合施工單位方法人員，防止過度坍落度。恰當?shù)母拍睿翰⒉皇翘涠仍酱螅禄炷猎饺菀?，而是要調整和易性和砂石的用量。這都是非常合理的，并且很可能控制攪拌設備的用水量。大家在實際操作中一定要小心，防止放縱水源。

3. Communication with the construction unit at the construction site of mixing equipment is very important. In order to get the understanding of the construction team, it is necessary to cooperate with the method personnel of the construction unit to prevent excessive slump. Proper concept: it is not that the greater the slump, the easier the underwater concrete is, but to adjust the workability and the amount of sand and gravel. This is very reasonable, and it is likely to control the water consumption of the mixing equipment. We must be careful in actual operation to prevent indulgence of water sources.

此外清洗平口攪拌車的水箱也是不能忽視的，可以這樣做：

In addition, cleaning the water tank of the flat mixer truck is also a key point that can not be ignored. This can be done:

裝車后，用清水沖洗進水口，將進水口附近剩余的混凝土清洗干凈，防止運輸后干燥后的混凝土吸附在進水口上。干燥的混凝土不容易清洗。每次運輸混凝土?xí)r，進料口都要用水沖洗，以保持裝載的混凝土入口濕潤。在工地卸料后，及時用自帶的清洗水沖洗卸料槽，然后在混凝土儲罐中加入一些清水，保證車輛返回時混凝土儲罐緩慢轉動。

After loading, wash the water inlet with clean water and clean the remaining concrete near the water inlet to prevent the dried concrete from adsorbing on the water inlet after transportation. Dry concrete is not easy to clean. Each time the concrete is transported, the feed inlet shall be flushed with water to keep the loaded concrete inlet wet. After unloading at the construction site, wash the unloading tank with its own cleaning water in time, and then add some clean water to the concrete storage tank to ensure that the concrete storage tank rotates slowly when the vehicle returns.

及時將水箱內的混凝土殘?jiān)粮?，防止混凝土吸附在水箱?nèi)壁上。當它到達攪拌站并重新填充混凝土?xí)r，將水箱中的清水排出并重復相同的步驟。將混凝土輸送到罐體和進料口時，避免混凝土吸附；裝砼時，不要偷懶，將隨車自帶的洗車水箱灌滿洗車水不加水。

Wipe the concrete residue in the water tank in time to prevent the concrete from adsorbing on the inner wall of the water tank. When it reaches the mixing plant and refills the concrete, first drain the clean water from the water tank and repeat the same steps. Avoid concrete adsorption when transporting concrete to tank and feed inlet; When loading concrete, do not be lazy. Fill the car washing water tank with car washing water without adding water.

水泥自動攪拌車工作時，必須仔細清潔油箱體、進料口、出料槽以及輪胎粘附混凝土的所有地方，以確保車輛的整體清潔度，采取一些措施讓您的工具持續更長時間。

When working, you must carefully clean the fuel tank body, feed inlet, discharge chute and all places where the tire adheres to the concrete to ensure the overall cleanliness of the vehicle. Take some measures to make your tools last longer.

相關問題的解答就是這樣了，平日里車主們也要做好定期的檢查維護工作，這樣能保障設備的完好以及人員的。更多內容咨詢就來關注我們的網站f3328.cn吧！

This is the answer to relevant questions. On weekdays, car owners should also do a good job in regular inspection and maintenance, so as to ensure the integrity of equipment and the safety of personnel. For more information, please visit our website at www.sdzkjf.com Cn!