皮帶輸送具有輸送能力強，輸送距離遠，結構簡單易于維護，能方便地實行程序化控制和自動化操作。自上料水泥攪拌車不能缺少皮帶輸送機，利用皮帶輸送機運送物料等，因此，在使用時，也需要注意維護和保養。

Belt conveyor has the advantages of strong conveying capacity, long conveying distance, simple structure, easy maintenance, and convenient programmed control and automatic operation. The self feeding cement mixer truck cannot lack belt conveyor and use belt conveyor to transport materials. Therefore, it also needs to pay attention to maintenance when in use.

傳動裝置的維護與保養。使用前應加潤滑油，潤滑油牌號為LKC100，150#中負荷極壓工業齒輪油。滾簡軸承的潤滑。滾簡軸承為UCP系列（常用UCP214），用潤滑脂潤滑，每天加油一次。

Maintenance of transmission device. Add lubricating oil before use. The brand of lubricating oil is lkc100150# medium load extreme pressure industrial gear oil. Lubrication of roller bearings. The plain roller bearing is UCP series (commonly used ucp214), which is lubricated with grease and filled once a day.

滾簡與托輥的清理。自上料水泥攪拌車，經常清理滾簡和托輥上的積料，積料過多會影響皮帶的運行，出現跑偏的情況。定期檢查刮砂裝置的磨損程度，刮砂裝置磨損到一定程度后及時更換。橡皮擋邊磨損嚴重，有料撒出時應及時更換。

Cleaning of roller and idler. Since the cement mixer truck is loaded, the accumulated materials on the roller and idler are often cleaned. Too much accumulated materials will affect the operation of the belt and lead to deviation. Regularly check the wear degree of the sand scraping device, and replace the sand scraping device in time after it is worn to a certain extent. The rubber retaining edge is seriously worn and should be replaced in time when materials are scattered.

接口斷裂及橫向撕裂的防范及處理。接頭硫化處理不合格；沖擊負載過大，薄弱部分受交變應力影響斷裂；接口方向與皮帶運動方向不合適；長期使用等，嚴重損壞皮帶。

Prevention and treatment of interface fracture and transverse tear. The joint vulcanization treatment is unqualified; The impact load is too large, and the weak part breaks under the influence of alternating stress; The interface direction is not suitable for the belt movement direction; If it is used for a long time, the belt will be seriously damaged.

自上料水泥攪拌車在使用時要盡量減少負載，特別是有配重張緊裝置的皮帶，應控制配重在200kg~300kg內，以雨季不打滑為宜，加強巡查，防止異物卡死皮帶，劃傷皮帶；加強對皮帶裝配人員的培訓，防止皮帶接口方向裝反。

When using the self loading cement mixer truck, the load shall be reduced as much as possible, especially the belt with counterweight tensioning device. The counterweight shall be controlled within 200kg ~ 300kg, and it is better not to slip in rainy season. Patrol inspection shall be strengthened to prevent foreign matters from blocking the belt and scratching the belt; Strengthen the training of belt assembly personnel to prevent reverse installation of belt interface.

攪拌車在露天場地停放時，裝料前應先將攪拌筒反轉，把筒內的積水（或雨水）和雜物卸出，以保證運送混凝土的質量。攪拌車在空載運行及運送混凝土過程中，攪拌筒不得停止轉動以免滾道、滾輪局部碰損或混凝土產生離析現象。

When the mixer truck is parked in the open field, the mixing drum shall be reversed before loading, and the ponding (or rainwater) and sundries in the drum shall be unloaded to ensure the quality of concrete transportation. During the no-load operation and concrete transportation of the mixer truck, the mixing drum shall not stop rotating, so as to avoid local collision damage of the raceway and roller or segregation of the concrete.

此外，在公路上行駛時，加長溜槽必須翻轉放置在卸料溜槽上用掛鉤掛牢，再轉與車身垂直部位，用鎖緊裝置把卸料溜槽和加長溜槽鎖緊在機架上，防止由于不固定而搖動，造成傷人事故和影響其它車輛運行。

In addition, when driving on the road, the extended chute must be turned over and placed on the discharge chute, hung firmly with a hook, and then turned to the position perpendicular to the vehicle body. The discharge chute and the extended chute are locked on the frame with a locking device to prevent shaking due to instability, resulting in personal injury accidents and affecting the operation of other vehicles.

自上料水泥攪拌車的皮帶輸送有注意事項的相關內容就是這樣了，當然定期的檢查維護是必不可少的，希望對大家有所幫助。更多內容就來網站f3328.cn進行咨詢吧。

This is the relevant content of precautions for belt conveying of self feeding cement mixer truck. Of course, regular inspection and maintenance are essential. I hope it will be helpful to you. For more information, please visit www.sdzkjf.com Cn for consultation.