Self loading Mini mixer is a machine that mixes cement, sand, aggregate and water to make concrete. It is mainly composed of mixing drum, feeding and discharging mechanism, water supply system, prime mover, transmission mechanism, frame and supporting device. As only safe and reasonable operation of the equipment can improve the performance of the equipment, the following will introduce the safe operation procedures of the equipment.

1.駕駛之前，必須仔細檢查車輛的狀況，以確保車輛可以行駛。

1. Before driving, you must carefully check the condition of the vehicle to ensure that the vehicle can drive safely.

2.將自上料微型攪拌車停放在露天場所時，在裝料前應將攪拌筒倒轉，并排出積聚的水和碎屑以確?；炷恋馁|(zhì)量。

2. When the self loading Mini mixer is parked in the open place, the mixing drum should be turned upside down before loading, and the accumulated water and debris should be discharged to ensure the quality of concrete.

3.運輸混凝土?xí)r，請確保牢固放置傾斜的槽，以防止因松動而搖擺，在行駛過程中傷害行人或影響其他車輛的正常運行，同時要注意避免混凝土溢出和污染地面。

3. When transporting concrete, please make sure that the inclined slot is firmly placed to prevent swinging due to looseness, causing injury to pedestrians or affecting the normal operation of other vehicles during driving, and at the same time, pay attention to avoid concrete overflow and polluting the ground.

4.自上料微型攪拌車的運輸時間不得超過攪拌站規定的時間。在運輸混凝土的過程中，攪拌桶不應長時間停頓以防止混凝土偏析。駕駛員應始終觀察具體情況，發現異常應通知主控制室，并進行。

4. The transportation time of self loading Mini mixer shall not exceed the specified time of mixing station. In the process of transporting concrete, the mixing bucket should not be stopped for a long time to prevent concrete segregation. The driver should always observe the specific situation, and inform the main control room if any abnormality is found, and carry out treatment.

5.將混凝土安裝在轎廂中時，現場停滯時間不得超過1小時。如果超過超時時間，則應要求網站負責人及時處理。

5. When the concrete is installed in the car, the on-site dead time shall not exceed 1 hour. If the timeout is exceeded, the person in charge of the website shall be required to deal with it in time.

6.當自上料微型攪拌車通過非泵運輸時，應將其從混凝土排到罐中。高溫時，不得超過2小時。如果超過2小時，則必須將其排出。雨天溫度較低時，不應超過2.5小時。

6. When the self loading Mini mixer is transported by non pump, it shall be discharged from the concrete into the tank. At high temperature, not more than 2 hours. If more than 2 hours, it must be discharged. When the temperature is low in rainy days, it should not exceed 2.5 hours.

7.在卸出混凝土之前，攪拌筒應以10-12 rpm的轉速旋轉1分鐘，然后卸出。

7. Before discharging the concrete, the mixing drum should be rotated at 10-12 rpm for 1 minute and then discharged.

8.自上料微型攪拌車完成后，應從車輛的軟管中排干水，并沖洗并排凈進料口，卸料斗和卸料槽，以除去附著在車體上的污垢和殘留混凝土。保持車輛衛生。

8. After the completion of loading the mini mixer, the water shall be drained from the hose of the vehicle, and the feed inlet, discharge hopper and discharge tank shall be washed and drained to remove the dirt and residual concrete attached to the vehicle body. Keep the vehicle clean.