Method 1

1、準備好緊急驅動軟管，將故障商品混凝土水泥攪拌運輸車熄火，卸下液壓馬達上的高壓油管接頭。

1. Prepare the emergency drive hose, turn off the fire of the cement mixer truck, and remove the high-pressure oil pipe joint on the hydraulic motor.

2、將救援車熄火，將其液壓馬達的高壓油管卸下，并與故障車上的對應接頭用緊急驅動軟管相連。

2. Turn off the fire of the rescue vehicle, remove the high-pressure oil pipe of its hydraulic motor, and connect it with the corresponding connector on the fault vehicle with emergency drive hose.

3、發動救援車，將其操縱手柄撥出料位置，故障車內的商品混凝土即被排出。

3. Start the rescue vehicle, turn its control handle to the discharging position, and the commercial concrete in the fault vehicle will be discharged.

4、緊急驅動完畢后，將驅動軟管卸下，并恢復兩車原狀。

4. After the emergency drive, remove the drive hose and restore the original state of the two vehicles.

方法二：

Method 2

1、若個方法實行有困難，則必須采用以下方法，立即排出商品混凝土。

1. If the first method is difficult to implement, the following methods must be adopted to discharge the commercial concrete immediately.

2、在托輪和滾道之間放入木楔，以控制攪拌筒的旋轉，一定要注意;將發動機熄火，拆松液壓馬達的一根高壓油管，攪拌筒可自由旋轉，控制攪拌筒的旋轉，使維修孔轉到下部，然后打開維修孔，清理出筒內商品混凝土。此時一定要注意，商品混凝土排出完畢后，恢復商品混凝土水泥攪拌運輸車原狀。

2. Put a wooden wedge between the supporting roller and the raceway to control the rotation of the mixing drum. Be sure to pay attention to safety. Turn off the engine and loosen a high-pressure oil pipe of the hydraulic motor. The mixing drum can rotate freely and control the rotation of the mixing drum to make the maintenance hole turn to the lower part, and then open the maintenance hole to clean out the commercial concrete in the cylinder. At this time, we must pay attention to safety, after the completion of commercial concrete discharge, restore the original state of commercial concrete cement mixing truck.

緊急清理水泥攪拌運輸車內商品混凝土是每個水泥攪拌運輸車司機都應該會的，在水泥攪拌運輸車發生故障的時候，及時清理，將損失降到。

Emergency cleaning of commercial concrete in cement mixer truck is what every cement mixer truck driver should know. When the cement mixer truck breaks down, clean it in time to minimize the loss.