1. Check whether the concrete mixer of Zhongke is smooth and whether the four legs are firmly supported;

　　2. 機器空載運行是否正常;

　　2. Whether the machine operates normally without load;

　　3.將泵注滿水并測試一次;

　　3. Fill the pump with water and test once;

　　4. 檢查電器接地情況。

　　4. Check the electrical grounding.

　　二是自上料水泥攪拌車的使用要求

　　Second, the use requirements of concrete mixer

　　1.每次添加的攪拌料不得超過規定的值，料斗只有在攪拌出后才能提起進料;

　　1. The mixing material added each time shall not exceed the specified value, and the hopper can only lift the feed after mixing out;

　　2.攪拌缸反轉時，切勿拉操作手柄;

　　2. When the mixing cylinder is reversed, do not pull the operating handle;

　　3.為減少粘罐現象，進料斗的順序?yàn)槭^-水泥-沙子或沙子-水泥-石頭;

　　3. In order to reduce tank sticking, the order of feeding hopper is stone cement sand or sand cement stone;

　　4.攪拌桶進料時及時加水，縮短攪拌時間，減少粉塵飛揚;

　　4. Add water in time when feeding the mixing barrel to shorten the mixing time and reduce dust flying;

　　5.料斗抬起后，任何人不得停留或從料斗下通過;當必須在料斗下進行維修時，應先用鏈將料斗緊固，才能進行維修。

　　5. After the hopper is lifted, no one is allowed to stay or pass under the hopper; when maintenance must be carried out under the hopper, the hopper shall be fastened with safety chain before maintenance.

　　6.嚴禁非工作人員隨意拉動控制手柄;機器不運轉時，必須用鉤固定;

　　6. It is strictly prohibited for non staff to pull the control handle at will; when the machine is not running, it must be fixed with a safety hook;

　　7、注意電氣，經常檢查地面是否良好，防止電機受潮，防止損壞電氣元件、電線;

　　7. Pay attention to electrical safety, check whether the ground is in good condition, prevent the motor from getting damp, and prevent damage to electrical components and wires;

　　8.當斷電時，可以用曲柄搖動減速帶盤，將物料從氣缸中取出;

　　8. When the power is cut off, the crank can be used to shake the reduction belt plate to take out the material from the cylinder;

　　9.當機器停放時，必須放下四個支撐腳來支撐機器的重量;

　　9. When the machine is parked, four supporting feet must be put down to support the weight of the machine;

　　3自上料水泥攪拌車的完成要求

　　3 requirements for completion of concrete mixer

　　1.停機前，應加入一定量的石子和水，攪拌5-10分鐘后釋放，以缸內堆積，避免粘罐;

　　1. Before shutdown, a certain amount of stones and water shall be added and released after mixing for 5-10 minutes to eliminate accumulation in the cylinder and avoid tank sticking;

　　2. 清潔有灰堆積和粘著的混凝土;

　　2. Clean the concrete with ash accumulation and adhesion;

　　3.將料斗置于輸送位置，懸掛鏈;所述控制手柄由鉤固定;

　　3. Place the hopper in the conveying position and hang the safety chain; the control handle is fixed by the safety hook;

　　4. 切斷電源，鎖好電箱;

　　4. Cut off the power supply and lock the electric box;

　　5. 在嚴寒季節，將供水系統的水全部排干;

　　5. In the severe cold season, drain all the water in the water supply system;

　　6. 向每個潤滑點添加必要的潤滑油。

　　6. Add necessary lubricating oil to each lubricating point.

　　以上是水泥自動攪拌車廠家小編為大家介紹的相關內容，想要了解更多內容，歡迎訪問網站：http://f3328.cn

　　The above is the relevant content introduced to you by China Science and technology concrete mixer manufacturer. To learn more, please visit the website: http://f3328.cn