水泥自動攪拌車是一種具備危險性質的設備，所以使用的時候要萬分注意，尤其是從出車到卸料的過程要操作正確，不然非常容易出現問題，那么下面講講注意事項吧。認真檢查，及時發現并排除故障。

　　Cement automatic mixer is a kind of dangerous equipment, so pay attention to the use of time, especially from the car to the unloading process to operate correctly, otherwise it is very prone to problems, then the following points for attention. Careful inspection, timely discovery and troubleshooting.

　　開車前注意檢查。點火前檢查發動機機油、防凍液、潤滑油和冷卻水，不足時重新添加。水泥自動攪拌車啟動后，檢查輪胎氣壓和輪胎是否漏氣。檢查車燈，尤其是腰燈，確保它們照在輪胎邊緣。用抹布清潔后視鏡和兩側車窗。施工現場路況復雜，光線不好先保證視線！

　　Check before driving. Check engine oil, antifreeze, lubricating oil and cooling water before ignition, and re-add if insufficient. After the cement mixer starts, check the tire pressure and tire leakage. Check your headlights, especially your waist lights, to make sure they shine on the edge of your tires. Clean the mirrors and side Windows with a rag. Construction site road conditions are complex, the light is not good to ensure sight first!

　　確保水箱中有足夠的水，并且有減水劑。由于各種原因，當物料太干，無水不能排放時，減水劑是救命稻草，否則鍋?zhàn)訒?huì)悶等一萬大洋。確認攪拌罐已停止。發動機起動時，如果罐處于高速旋轉狀態，瞬時力會很大，減速器會損壞。

　　Make sure there is enough water in the tank and there is water reducing agent. For a variety of reasons, when the material is too dry to discharge without water, high-efficiency water reducer is a lifesaver, otherwise the pot will be boring waiting for ten thousand dollars. Make sure the mixing tank is stopped. When the engine starts, if the tank is in a state of high speed rotation, the instantaneous force will be large and the reducer will be damaged.

　　裝載時記得清潔。特別是車輛露天停放、下雨時，應將罐內積水、可能的樹葉等雜物排干，以免影響混凝土質量。清洗完畢后，關閉水箱進氣口，打開水箱出風口將氣體排出，因?yàn)樵趬毫ψ饔孟?，水管連接不好，容易滲漏，影響其他車輛的。再次檢查輪胎的石塊和鐵釘，因?yàn)橥＼嚂r(shí)無法檢測到輪胎與地面的接觸。

　　Remember to clean when loading. Especially when the vehicle is parked in the open air and it rains, the tank should be drained of water, possible leaves and other sundries, so as not to affect the quality of concrete. After cleaning, close the inlet of the water tank and open the outlet of the water tank to discharge the gas, because under the action of pressure, the water pipe is not connected well, easy leakage, affecting the safety of other vehicles. Check again for stones and nails as contact with the ground cannot be detected during parking.

　　開車要慢。攪拌車高，易于翻車！轉彎前提前減速降檔，轉彎時盡量不要踩剎車。始終通過后視鏡觀察罐是否轉動，并嘗試減慢速度。如果車速太高，車輛很容易擺動。在長時間行駛或下坡前，您應該習慣于測試制動器。對于重型車輛，不要掛空檔滑下山。下坡時，提前減速，然后減速，然后再減速。掛檔制動效果更好。

　　Drive slowly. Agitator high center of gravity, easy to overturn! Slow down and downshift before turning, and try not to brake when turning. Always look through the rearview mirror to see if the tank is rotating and try to slow it down. If the speed is too high, the vehicle will wobble easily. You should get used to testing the brakes before a long ride or downhill. For heavy vehicles, do not slide downhill in neutral. When going downhill, slow down early, then slow down, then slow down again. Gear braking works best.

　　倒車時一定要減速。不要總是把頭伸出窗外，要看兩邊的后視鏡。如果你不確定，停下來看清楚，然后翻過來。很多路都是挖掘機鋪的，所以車子很容易下沉。

　　Be sure to slow down when backing up. Don't always stick your head out of the window. Look in both mirrors. If you're not sure, stop and look, then flip over. Many roads are paved by excavators, so the car is easy to sink.

　　卸料前弄濕料斗溜槽。卸料時，應盡量將水泥自動攪拌車停放在平地上，卸料前應將卸料斗的溜槽打濕，以便于清洗。卸料時不要大意，要與卸料者保持良好關系。卸料時自己看著，以免卸料工人亂操作卸料桿。每次罐處于正反轉中間位置時更好停車，以保護減速器、托輪等。仔細清洗混合罐。

　　Wet hopper chute before unloading. When unloading, cement automatic mixing truck should be parked as far as possible on the level, before unloading should be wet discharge hopper chute, in order to facilitate cleaning. Don't be careless when unloading, keep a good relationship with the unloading person. Watch yourself when unloading, so as to avoid unloader to operate the unloading rod. It is best to stop every time the tank is in the middle position of positive and negative rotation to protect the reducer, supporting wheels, etc. Clean the mixing tank carefully.

　　水泥自動攪拌車從出車到卸料要注意什么？總之，這個過程中要注意的事項太多了，但所做的事項完全是為了保證自己的以及保障工作的完成，是值得的！更多內容就來網站f3328.cn咨詢吧！

　　Cement automatic mixer from the car to discharge what to pay attention to? All in all, there are too many things to pay attention to in this process, but it is worth doing to ensure their safety and guarantee the completion of the work! More content to the website f3328.cn consultation!