水泥自動攪拌車在挖掘工作中起著非常重要的作用，作為鉆井作業中不可缺少的機械之一，水泥自動攪拌車是為了保持鉆井液的均勻性和懸浮固相顆粒。下面我們就一起來了解下該機器吧。

　　Cement automatic mixer truck plays a very important role in excavation work, as one of the indispensable machinery in drilling operations, cement automatic mixer is to maintain the uniformity of drilling fluid and suspended solid particles. Let's get to know the machine.

　　水泥自動攪拌車主要用于鉆井液的混合和混合，防止鉆井液固相顆粒在其罐體循環系統中堆積，穩定循環鉆井液的性能，使混合均勻。水泥自動攪拌車適用于攪拌石油鉆井液，結構緊湊，風量?。凰嘧詣?dòng)攪拌車采用渦輪蝸輪減速器，傳遞扭矩大，運行穩定，運行可靠等特點。

　　Cement automatic mixer is mainly used for drilling fluid mixing and mixing, to prevent solid particles of drilling fluid from accumulating in its tank circulation system, stabilize the performance of circulating drilling fluid, so that the mixing is uniform. Cement automatic mixer is suitable for mixing petroleum drilling fluid, compact structure, small air volume; Cement automatic mixer adopts turbo worm gear reducer, transmission torque, stable operation, reliable operation and so on.

　　水泥自動攪拌車的保養技巧：

　　Maintenance skills of cement automatic mixing truck:

　　試機前檢查各連接件是否松動，必要時擰緊。

　　Before the test, check whether the connecting parts are loose and tighten them if necessary.

　　操作者應通過油位檢查減速機，看變速箱內潤滑油量是否充足。當潤滑油不足時，應充分加入同類型潤滑油。

　　The operator should check the reducer through the oil level to see if the lubricating oil in the gearbox is sufficient. When lubricating oil is insufficient, the same type of lubricating oil should be fully added.

　　檢查放油塞的密封情況，確認是否有漏油現象。如果有潤滑油泄漏，必須擰緊塞子。

　　Check the seal of drain plug to see if there is oil leakage. If lubricating oil leaks, the plug must be tightened.

　　試運行時，主要是觀察整機運轉是否平穩，噪音是否過大。如有異常應立即停止檢查，待故障排除后方可開始正常運行。

　　During trial operation, it is mainly to observe whether the whole machine runs smoothly and whether the noise is too large. If there is any abnormality, stop checking immediately and start normal operation after troubleshooting.

　　進入正常運轉后，短時間內要將變速箱內的潤滑油全部排盡，使變速箱清潔，更換干凈的潤滑油。

　　After entering normal operation, all the lubricating oil in the gearbox should be discharged in a short time, so that the gearbox is clean and the clean lubricating oil should be replaced.

　　在開挖工作中，攪拌機是不可缺少的機器，對開挖工作也很重要。所以以上所講內容希望對您有幫助，如果您還有其他方面的內容想知道，那就來此f3328.cn進行咨詢吧。

　　In the excavation work, the mixer is an indispensable machine and also very important to the excavation work. So the above content I hope to help you, if you have other aspects of the content you want to know, then go to f3328.cn for consultation.