，保證不離析，因?yàn)樵谌缃翊罅可a(chǎn)大坍度的混凝土的形勢下，如果滾筒不攪拌的情況下，嘿嘿，后果是你的攪拌車要花兩萬左右更換減速機的傳動軸，因?yàn)樵谶\(yùn)輸途中一直顛簸的情況下，砂石會沉淀在滾筒上，水會浮在上部，這就是所謂的離析，然后你到工地上想放料，突然發現滾筒轉不動了，只能轉1/4圈，然后整個車往一邊偏像要翻掉一樣，因?yàn)橹亓慷技性谝贿叄缓蟛皇欠嚲褪莻鲃?dòng)軸攪斷。（PS：攪拌車滾筒旋轉是要多耗油的，所以有些車就會偷偷不轉，老司機會隔10幾分鐘轉幾下，新手不知道就一直不轉，然后就悲劇了，當然我們公司用的是富士康的監控系統，滾筒不轉是會有監控的）
First, ensure that there is no segregation, because in today's situation of mass production of large slump concrete, if the drum does not mix, the consequence is that your mixer will spend about 20000 to replace the transmission shaft of the reducer, because in the case of bumpy transportation, the sand and gravel will settle on the drum, and the water will float on the top, which is called segregation, Then you go to the construction site and want to put the material. Suddenly you find that the drum can't rotate, it can only rotate 1 / 4 circle, and then the whole car turns to one side as if it's going to turn over, because the weight is concentrated on one side, and then it either overturns or the transmission shaft is broken（ PS: the rotation of mixer drum consumes more fuel, so some cars will not rotate secretly. The old company will rotate several times every 10 minutes, and the novice will not rotate until they know it. Then it's a tragedy. Of course, our company uses Foxconn's monitoring system, and there will be monitoring if the drum doesn't rotate.)
第二，是保坍，因?yàn)楦鶕?jù)實驗，混凝土在運輸途中不攪拌和攪拌大約坍度每小時會相差20mm40mm左右。做混凝土更重要的幾方面有一項就是坍度，直接影響施工性和工程質量。
The second is slump preservation, because according to the experiment, the slump difference between concrete without mixing and mixing during transportation is about 20 mm to 40 mm per hour. One of the most important aspects of concrete is slump, which directly affects the constructability and engineering quality.
第三，有部分?jǐn)嚢韫δ埽沁@個攪拌功能必須在滾筒快速旋轉的情況下會有一定效果，但是路上每分鐘幾轉的速度下攪拌效果不是太明顯，畢竟?jié)L筒內的葉片是螺旋形的并不是攪拌刀。
Third, there is part of the mixing function, but this mixing function must have a certain effect in the case of rapid rotation of the drum, but the mixing effect is not obvious at the speed of several revolutions per minute on the road. After all, the blades in the drum are spiral, not the mixing knife.
還是為了防止凝固。一般而言，初凝時間在45分鐘左右，即凝固了影響質量，所以在運輸過程中不停地轉動防止這個事情，當然，如果距離很長，可能還要加一些緩凝劑，進一步防止凝固。
Or to prevent solidification. Generally speaking, the initial setting time is about 45 minutes, that is to say, the quality is affected by solidification. Therefore, it is necessary to rotate continuously during transportation to prevent this. Of course, if the distance is very long, some retarders may be added to further prevent solidification.
Cement automatic mixer shared the above content for you today. For more details, please contact us: http://f3328.cn We have a lot of follow-up content for you
上一篇：3方小型水泥自上料攪拌車的使用特點
下一篇：混凝土攪拌車節省燃料消耗在于習慣？
