1、 Engine fault.

1.傳動軸損壞，應立即替換傳動軸。

1. If the transmission shaft is damaged, replace it immediately.

2.查看液壓油是否有走漏，管子是否密封完好，如有損壞應立即替換。

2. Check whether there is leakage of hydraulic oil and whether the pipe is well sealed. If there is damage, replace it immediately.

自動攪拌車

Concrete mixer

3.查看油泵控制閥擺桿是否正常擺動(駕駛室內與尾部擺動均無效果，此處可手動操作正回轉，后查看各連接桿是否松動或損壞)。

3. Check whether the swing rod of the oil pump control valve swings normally (the swing in the cab and the tail has no effect, here you can manually operate the positive swing, and then check whether the connecting rods are loose or damaged).

4.查看一下散熱器風扇是否工作，液壓油乳化變白沒有，液壓油溫度超越90度，液壓系統就沒有壓力，罐子就不轉了。（這種狀況不要著急，用水冷卻一下液壓泵，液壓馬達，液壓油溫度下來，罐子就能夠轉動了。把料放出來，趕忙修理散熱器或替換液壓油）。

4. Check whether the radiator fan works, whether the hydraulic oil emulsification turns white, and whether the hydraulic oil temperature exceeds 90 degrees, the hydraulic system has no pressure, and the tank does not rotate. (don't worry about this situation. Cool down the hydraulic pump, motor and oil with water, and the tank will be able to rotate. Put out the material and repair the radiator or replace the hydraulic oil.

自動攪拌車

Concrete mixer

5.液壓泵損壞了（狀況復雜一點，內瀉嚴峻，其他損壞）。

5. The hydraulic pump is damaged (the condition is more complicated, the internal drainage is severe, and other damages).

二、液壓馬達損壞了或減速機壞了

2、 The hydraulic motor is damaged or the reducer is damaged

這兩種狀況出現，不能運用應急裝置。能夠?qū)⒐摅w上的查看蓋翻開將混凝土放出。

These two situations occur, and emergency devices cannot be used. Be able to open the inspection cover on the can body to release the concrete.

自動攪拌車

Concrete mixer

三、運輸途中沒有留意，罐子停了?；炷了×?，罐子翻不過去。如果在加油門感覺時有壓力能轉就可能是這種狀況。

3、 Didn't pay attention to the transportation. The pot stopped. The concrete has collapsed and the jar can't be turned over. This may be the case if there is pressure to turn when the gas door feels like it.

1，檢修孔在罐體上方怎么辦？能夠用塔機、卷揚機將罐體查看蓋旋轉到下方，將混凝土放出；

1. What about the manhole above the tank? Be able to use tower crane and winch to rotate the tank inspection cover to the bottom to release the concrete;

2，罐子卡住了旋轉不動怎么辦？能夠在罐體側下方用氣割開一個50厘米見方的孔（留意避開罐里的螺旋葉片，割下的罐壁必定保留，修復起來迅速、便利而且漂亮），將混凝土放

2. What if the jar is stuck and doesn't rotate? It can cut a 50 cm square hole under the side of the tank with gas (pay attention to avoid the spiral blade in the tank, the cut tank wall must be kept, and the repair is quick, convenient and beautiful). Put the concrete